P0464 Code: Meaning, Symptoms, Causes & Fix

Overview

Symptoms

• failed emissions test readiness
• rough idle under load
• check engine light

Common causes

• Temperature/vibration related circuit dropout affecting evaporative emission control system pressure sensor intermittent / fuel level sensor circuit intermittent
• Connector pin fit issue
• Connector pin damage/corrosion or harness stress near related components

How to diagnose P0464

1. Confirm P0464 and capture freeze-frame data with a professional scan tool.
2. Inspect wiring, connectors, and grounds related to evaporative emission control system pressure sensor intermittent / fuel level sensor circuit intermittent for obvious defects.
3. Reproduce the fault with harness movement and heat/vibration checks.
4. Check for related DTCs to identify the root-cause chain before replacing parts.
5. After repair, clear codes and confirm readiness monitors complete without recurrence.

Severity of code P0464

Moderate: This code is moderate severity: the vehicle may still operate, but fault progression can increase repair cost over time.

Can you drive with P0464?

Most vehicles can be driven short-term with P0464, but postpone heavy load/highway driving until repaired.

If the warning lamp is flashing or drivability/safety is affected, avoid driving and diagnose immediately.

How to fix it (step-by-step)

1. Repair obvious wiring/connector faults first to prevent repeat parts replacement.
2. Address the root fault mode (intermittent) in the evaporative emission control system pressure sensor intermittent / fuel level sensor circuit intermittent circuit/system.
3. Apply the required relearn/adaptation procedure if specified by service information.
4. Road-test and verify P0464 remains cleared under the conditions that originally set the code.

Fix options

• Wiggle-test harness during live monitoring.
• Repair intermittent connector contact.
• Clear DTCs and verify with live data and completed drive cycle.

Typical repair cost

$180-$900

Common mistakes when diagnosing P0464

• Replacing parts without verifying voltage, ground, and signal integrity first.
• Ignoring related stored/pending codes that indicate upstream faults.
• Skipping post-repair verification drive cycle and readiness checks.

P0464 in common vehicles

P0464 appears across makes such as Ford, Toyota, Honda, Chevrolet. Failure patterns differ by platform: wiring routes, software calibration, and component supplier revisions can change root cause.

Frequently asked questions

What causes P0464?

P0464 is commonly set by intermittent faults affecting evaporative emission control system pressure sensor intermittent / fuel level sensor circuit intermittent.

How much does it cost to fix P0464?

For P0464, repair costs are typically $180-$900 depending on exact root cause, labor rates, and part quality.

Can I clear P0464 without repair?

You can clear P0464 temporarily, but the code usually returns until the underlying fault is corrected.

Helpful tools

• Estimate repair cost
• Decode your VIN
• Calculate fuel cost