P0624 Code: Meaning, Symptoms, Causes & Fix

Overview

Symptoms

• reduced fuel economy
• hesitation under acceleration
• engine may stall at idle

Common causes

• Disconnected or loose connector affecting fuel cap lamp control circuit
• Open circuit in wiring
• Connector pin damage/corrosion or harness stress near related components

How to diagnose P0624

1. Confirm P0624 and capture freeze-frame data with a professional scan tool.
2. Inspect wiring, connectors, and grounds related to fuel cap lamp control circuit for obvious defects.
3. Use a continuity test from module pin to component to identify opens/high resistance.
4. Check for related DTCs to identify the root-cause chain before replacing parts.
5. After repair, clear codes and confirm readiness monitors complete without recurrence.

Severity of code P0624

Moderate: This code is moderate severity: the vehicle may still operate, but fault progression can increase repair cost over time.

Can you drive with P0624?

Most vehicles can be driven short-term with P0624, but postpone heavy load/highway driving until repaired.

If the warning lamp is flashing or drivability/safety is affected, avoid driving and diagnose immediately.

How to fix it (step-by-step)

1. Repair obvious wiring/connector faults first to prevent repeat parts replacement.
2. Address the root fault mode (open) in the fuel cap lamp control circuit circuit/system.
3. Apply the required relearn/adaptation procedure if specified by service information.
4. Road-test and verify P0624 remains cleared under the conditions that originally set the code.

Fix options

• Repair open circuit and secure connector lock.
• Clear corrosion and protect terminals.
• Clear DTCs and verify with live data and completed drive cycle.

Typical repair cost

$220-$1100

Common mistakes when diagnosing P0624

• Replacing parts without verifying voltage, ground, and signal integrity first.
• Ignoring related stored/pending codes that indicate upstream faults.
• Skipping post-repair verification drive cycle and readiness checks.

P0624 in common vehicles

P0624 appears across makes such as Ford, Toyota, Honda, Chevrolet. Failure patterns differ by platform: wiring routes, software calibration, and component supplier revisions can change root cause.

Frequently asked questions

What causes P0624?

P0624 is commonly set by open faults affecting fuel cap lamp control circuit.

How much does it cost to fix P0624?

For P0624, repair costs are typically $220-$1100 depending on exact root cause, labor rates, and part quality.

Can I clear P0624 without repair?

You can clear P0624 temporarily, but the code usually returns until the underlying fault is corrected.

Helpful tools

• Estimate repair cost
• Decode your VIN
• Calculate fuel cost