P1691 Code: Meaning, Symptoms, Causes & Fix

Overview

Symptoms

• poor throttle response
• occasional limp mode
• surging or unstable idle

Common causes

• Disconnected or loose connector affecting turbo pressure control solenoid circuit malfunction
• Open circuit in wiring
• Connector pin damage/corrosion or harness stress near related components

How to diagnose P1691

1. Confirm P1691 and capture freeze-frame data with a professional scan tool.
2. Inspect wiring, connectors, and grounds related to turbo pressure control solenoid circuit malfunction for obvious defects.
3. Use a continuity test from module pin to component to identify opens/high resistance.
4. Check for related DTCs to identify the root-cause chain before replacing parts.
5. After repair, clear codes and confirm readiness monitors complete without recurrence.

Severity of code P1691

Moderate: This code is moderate severity: the vehicle may still operate, but fault progression can increase repair cost over time.

Can you drive with P1691?

Most vehicles can be driven short-term with P1691, but postpone heavy load/highway driving until repaired.

If the warning lamp is flashing or drivability/safety is affected, avoid driving and diagnose immediately.

How to fix it (step-by-step)

1. Repair obvious wiring/connector faults first to prevent repeat parts replacement.
2. Address the root fault mode (open) in the turbo pressure control solenoid circuit malfunction circuit/system.
3. Apply the required relearn/adaptation procedure if specified by service information.
4. Road-test and verify P1691 remains cleared under the conditions that originally set the code.

Fix options

• Restore continuity and verify pin tension.
• Clear corrosion and protect terminals.
• Clear DTCs and verify with live data and completed drive cycle.

Typical repair cost

$180-$900

Common mistakes when diagnosing P1691

• Replacing parts without verifying voltage, ground, and signal integrity first.
• Ignoring related stored/pending codes that indicate upstream faults.
• Skipping post-repair verification drive cycle and readiness checks.

P1691 in common vehicles

P1691 appears across makes such as Mazda, Subaru, Lexus, Jeep. Failure patterns differ by platform: wiring routes, software calibration, and component supplier revisions can change root cause.

Frequently asked questions

What causes P1691?

P1691 is commonly set by open faults affecting turbo pressure control solenoid circuit malfunction.

How much does it cost to fix P1691?

For P1691, repair costs are typically $180-$900 depending on exact root cause, labor rates, and part quality.

Can I clear P1691 without repair?

You can clear P1691 temporarily, but the code usually returns until the underlying fault is corrected.

Helpful tools

• Estimate repair cost
• Decode your VIN
• Calculate fuel cost